Advantech PCM-3362 Manual do Utilizador

User ManualPCM-3362PC/104-plus SBC withIntel® Atom™ N450, VGA, LCD, LAN, USB2.0, SATA, and on-board flash

PCM-3362 User Manual 21.1 IntroductionThe PCM-3362 is a fanless, low power, small size (96X90mm), performance PC/104-plus SBC (Single Board Computer)

3 PCM-3362 User ManualChapter 1 General Information 2nd Cache Memory: 512 KB on the processor System Chipset: Intel® ICH8M BIOS: AMI 16Mbit Flash B

PCM-3362 User Manual 4– Power on - Boot: Measure the maximum current value of between system power on and boot-up to O.S.– Max. load: Measure the maxi

5 PCM-3362 User ManualChapter 1 General InformationFigure 1.2 Board layout: Dimensions (Solder Side)

PCM-3362 User Manual 6

Chapter 22 Hardware Installation

PCM-3362 User Manual 8This chapter explains the setup procedures of the PCM-3362 hardware, includinginstructions on setting jumpers and connecting per

9 PCM-3362 User ManualChapter 2 Hardware Installation2.3 Locating Connectors & block diagramFigure 2.1 Connectors (component side)Figure 2.2 Conne

PCM-3362 User Manual 10Figure 2.3 Block diagram2.4 Setting JumpersYou may configure your card to match the needs of your application by setting jump-e

11 PCM-3362 User ManualChapter 2 Hardware InstallationThe jumper settings are schematically depicted in this manual as follows:A pair of needle-nose p

PCM-3362 User Manual iiCopyrightThe documentation and the software included with this product are copyrighted 2009by Advantech Co., Ltd. All rights ar

PCM-3362 User Manual 122.4.3 COM3 RS422/RS485 Select (JP3)2.4.4 PCI I/O Voltage Select (JP4)The PCI Host board will always determine the PCI signaling

13 PCM-3362 User ManualChapter 2 Hardware InstallationPCM-3362 supports 2GB industrial grade NAND NANDriveTM IC and up to 4GB foroption. Flash enduran

PCM-3362 User Manual 14Reset (Pin3 & Pin4)If you install a reset switch, it should be an open single pole switch.Momentarily pressing the switch w

15 PCM-3362 User ManualChapter 2 Hardware Installation2.16 GPIO Connector (CN21)The board supports 8-bit GPIO through GPIO connector. The 8 digital in

PCM-3362 User Manual 16

Chapter 33 AMI BIOS Setup

PCM-3362 User Manual 18AMIBIOS has been integrated into many motherboards for over a decade. With theAMIBIOS Setup program, you can modify BIOS settin

19 PCM-3362 User ManualChapter 3 AMI BIOS SetupFigure 3.2 Main setup screenThe Main BIOS setup screen has two main frames. The left frame displays all

PCM-3362 User Manual 20Figure 3.3 Advanced BIOS features setup screen 3.3.1 CPU ConfigurationFigure 3.4 CPU Configuration SettingMax CPUID Value Limit

21 PCM-3362 User ManualChapter 3 AMI BIOS SetupIntel® C-STATE techThis item allows the CPU to save more power under idle mode.Enhanced C-StatesCPU idl

iii PCM-3362 User Manual Packing ListBefore you begin installing your card, please make sure that the following materialshave been shipped:If any of t

PCM-3362 User Manual 223.3.3 Super I/O ConfigurationFigure 3.6 Super I/O ConfigurationSerial Port1 / Port2 / Port3 address This item allows you to sel

23 PCM-3362 User ManualChapter 3 AMI BIOS SetupTemperature & Voltage showCPU/System Temperature Vcore / +3.3Vin / +5Vin / +12Vin / VBAT3.3.5 ACPI

PCM-3362 User Manual 243.3.5.2 Advanced ACPI Configuration Figure 3.10 Advanced ACPI ConfigurationACPI Version Features This item allows you to enable

25 PCM-3362 User ManualChapter 3 AMI BIOS SetupEnergy Lake Feature Allows you to configure Intel's Energy Lake power management technology. APIC

PCM-3362 User Manual 263.3.7 APM ConfigurationFigure 3.13 APM Configuration Power Management/APMEnable or disable APM. Power Button Mode Power on, off

27 PCM-3362 User ManualChapter 3 AMI BIOS Setup3.3.8 Event Log ConfigurationFigure 3.14 South Bridge ACPI ConfigurationView Event Log View all unread

PCM-3362 User Manual 283.3.10 Smbios ConfigurationFigure 3.16 South Bridge ACPI ConfigurationSmbios Smi SupportSMBIOS SMI wrapper support for PnP func

29 PCM-3362 User ManualChapter 3 AMI BIOS SetupBIOS EHCI Hand-OffThis is a workaround for OSes without EHCI hand-off support. The EHCI ownershipchange

PCM-3362 User Manual 30Figure 3.19 PCI/PNP Setup (top)Clear NVRAMSet this value to force the BIOS to clear the Non-Volatile Random Access Memory(NVRAM

31 PCM-3362 User ManualChapter 3 AMI BIOS Setup3.5 Boot SettingsFigure 3.20 Boot Setup Utility 3.5.1 Boot settings ConfigurationFigure 3.21 Boot Setti

PCM-3362 User Manual iv2. This device must accept any interference received, including interference that may cause undesired operationFCC Class AThis

PCM-3362 User Manual 32Bootup Num-LockSelect the Power-on state for Numlock. PS/2 Mouse SupportSelect support for PS/2 Mouse. Wait For ‘F1’ If ErrorWa

33 PCM-3362 User ManualChapter 3 AMI BIOS Setup3.7 Advanced Chipset Settings Figure 3.23 Advanced Chipset Settings 3.7.1 North Bridge Chipset Configur

PCM-3362 User Manual 34Figure 3.25 Video function configurationDVMT Mode SelectDisplays the active system memory mode. DVMT/FIXED MemorySpecify the am

35 PCM-3362 User ManualChapter 3 AMI BIOS SetupUSB FunctionsDisabled, 2 USB Ports, or 4 USB Ports. USB 2.0 ControllerEnables or disables the USB 2.0 c

PCM-3362 User Manual 363.8.2 Discard Changes and Exit Select this option to quit Setup without making any permanent changes to the systemconfiguration

Chapter 44 Software Introduction & Installation

PCM-3362 User Manual 384.1 S/W Introduction The mission of Advantech Embedded Software Services is to "Enhance quality of lifewith Advantech plat

39 PCM-3362 User ManualChapter 4 Software Introduction & Installation4.3.2 Software APIsPCM-3362 supports software APIs including GPIO, I2C, backl

PCM-3362 User Manual 40– Make use of Intel SpeedStep technology to reduce power consumption. The system will automatically adjust the CPU Speed depend

41 PCM-3362 User ManualChapter 4 Software Introduction & InstallationThe following section illustrates the installation process.1. Extract Susi.zi

v PCM-3362 User Manual ContentsChapter 1 General Information ...11.1 Introduction ...

PCM-3362 User Manual 424.3.5 SUSI Sample ProgramsSample ProgramsThe sample programs demonstrate how to incorporate SUSI into your program.There are sa

43 PCM-3362 User ManualChapter 4 Software Introduction & Installation When the application is executed, it will display GPIO information in the GP

PCM-3362 User Manual 44and 1 high, 3 to low, the pin number should be ‘0x0B/, and then you should key in the value ‘0x0A’ to write.– Click the WRITE G

45 PCM-3362 User ManualChapter 4 Software Introduction & Installation– Click the radio button- Access a byte.– Key in the slave device address in

PCM-3362 User Manual 46Display ControlWhen the application is executed, it will display two blocks of VGA control functions.The application can turn o

47 PCM-3362 User ManualChapter 4 Software Introduction & Installation Set the timeout value 3000 (3 sec.) in the SET TIMEOUT field and set the de

PCM-3362 User Manual 48

Chapter 55 Chipset Software Installation Utility

PCM-3362 User Manual 505.1 Before You BeginTo facilitate the installation of the enhanced display drivers and utility software, readthe instructions i

Chapter 66 Integrated Graphic Device Setup

PCM-3362 User Manual viChapter 3 AMI BIOS Setup... 17Figure 3.1 Setup program initial screen...

PCM-3362 User Manual 526.1 IntroductionTo benefit from the Intel® Atom N450 integrated graphics controller, you need toinstall the graphic driver.6.2

Chapter 77 LAN Configuration

PCM-3362 User Manual 547.1 IntroductionThe PCM-3362 has Gigabit Ethernet LAN via dedicated PCI Express x 1 lanes (Intel82567V), that offer bandwidth o

Appendix AA Pin AssignmentsThis appendix contains informa-tion of a detailed or specialized nature. Sections include: Jumper and Connector Tables

PCM-3362 User Manual 56A.1 Jumper and Connector TablesJP1 CLEAR CMOSPart Number 1653003101Footprint JH3X1V-2MDescription PIN HEADER 3*1P 180D(M) 2.0mm

57 PCM-3362 User ManualAppendix A Pin AssignmentsPart Number 1653002101Footprint JH2X1V-2MDescription PIN HEADER 2*1P 180D(M)SQUARE 2.0mm DIP W/O PbSe

PCM-3362 User Manual 588N/C9 LVDS0_z_D1- OUT LVDS10 N/C11 LVDS0_z_D2+ OUT LVDS12 N/C13 LVDS0_z_D2- OUT LVDS14 N/C1 5 LV D S 0 _ z _ C L K + O U

59 PCM-3362 User ManualAppendix A Pin AssignmentsCN9 USB0/1Part Number 1653003718Footprint PH5x2P-SR2.00Description PIN HEADER 5*2P 2.00mm 90D(M) NO.1

PCM-3362 User Manual 60CN12 Front panel Connector Part Number 1653008101 Footprint JH8X1V-2MDescription PIN HEADER 8*1P 180D(M) 2.0mm DIP 209-1*8GS Pi

61 PCM-3362 User ManualAppendix A Pin AssignmentsCN16 COM1~COM2 ConnectorPart Number 1653003720Footprint HD_10x2P_79_RADescription PIN HEADER 10*2P 2.

vii PCM-3362 User Manual Chapter 4Software Introduction & Installation...374.1 S/W Introduction...

PCM-3362 User Manual 62CN18 LAN ConnectorPart Number 1653003719Footprint HD_5x2P_79_RA_21N22050Description PIN HEADER 5*2P 2.00mm 90D(M) SMD 21N22050-

63 PCM-3362 User ManualAppendix A Pin AssignmentsCN21 GPIO ConnectorPart Number 1653010102Footprint JH10X1V-2MDescription PIN HEADER 10*1P 180D(M) DIP

PCM-3362 User Manual 64CN25 I2C BUS connectorPart Number 1653004101Footprint HD_4x1P_79_DDescription PIN HEADER 4*1P 180D(M) 2.0mm DIP WO/PbPin Pin Na

Appendix BB System AssignmentsThis appendix contains informa-tion of a detailed nature. Sections include: System I/O ports 1st MB memory map DMA ch

PCM-3362 User Manual 66B.1 System I/O Ports* PNP audio I/O map range from 220 ~ 250H (16 bytes) MPU-401 select from 300 ~330H (2 bytes)B.2 1st MB Memo

67 PCM-3362 User ManualAppendix B System Assignments* Audio DMA select 1, 3, or 5** Parallel port DMA select 1 (LPT2) or 3 (LPT1)B.4 Interrupt assignm

PCM-3362 User Manual 68

Appendix CC Mechanical Drawings

PCM-3362 User Manual 70C.1 Board Mechanical DrawingsFigure C.1 PCM-3362 Mechanical Drawing (Component Side)

71 PCM-3362 User ManualAppendix C Mechanical DrawingsFigure C.2 PCM-3362 Mechanical Drawing (Solder Side)

PCM-3362 User Manual viiiAppendix D Watchdog Timer and GPIO sample code... 75D.1 Watchdog Timer sampl

PCM-3362 User Manual 72C.2 Heatsink Mechanical DrawingsFigure C.3 PCM-3362N Heatsink Mechanical DrawingFigure C.4 PCM-3362Z/Z2 Heatsink Mechanical Dra

73 PCM-3362 User ManualAppendix C Mechanical DrawingsC.3 Optional Heat spreader Mechanical DrawingsFigure C.5 PCM-3362 optional Heatspreader Mechanica

PCM-3362 User Manual 74

Appendix DD Watchdog Timer and GPIO sample code

PCM-3362 User Manual 76D.1 Watchdog Timer sample code;The SCH3114 Runtime base I/O address is A00h;Setting WatchDog time value location at offset 66h;

77 PCM-3362 User ManualAppendix D Watchdog Timer and GPIO sample codeENDD.2 GPIO sample code;=========================================================

PCM-3362 User Manual 78; cl= n ; n means which group of GPIO you want to set; bl= the n group of gpio config; bit 0 = gpio 0 , 0 => outp

79 PCM-3362 User ManualAppendix D Watchdog Timer and GPIO sample code; bit 1 = gpio 1 , 0 => Low; 1 => High; ...; bit 7 = gpi

www.advantech.comPlease verify specifications before quoting. This guide is intended for referencepurposes only.All product specifications are subject

Chapter 11 General InformationThis chapter gives background information on the PCM-3362.Sections include: Introduction Features Specifications Boa